10/8/2013 Update
Posted by:
PowerMan
(129.65.27.---)
Posts: 252
Date: October 08, 2013 01:49PM
I have an irritating rattling noise that is coming from the NV4500. The noise is very noticeable at high RPM in 4th gear and in 5th after you let off the throttle. Sounds like there is a lot of slack between the gears or something of that nature. The NP205 is fresh with new bearings and the two piece driveline is rebalanced with all new 1410 u joints. I put the rear end on blocks and got it up to speed and the point were it makes the noise. Used a small piece of wood and held it up the clutch, trans, t-case, driveline support bearing, and rearend and listened for noise. Noise was definitely coming from transmission. The noise is still around even after rebuilding the transmission.
When I rebuild the trans I upgraded to a fully splined mainshaft and upgraded the 5th gear nut. Installed all new bearings/races, synchros, and cleaned everything as it was very dirty. New NV4500 oil from the dealer ($20/quart :banghead ) but it's the only oil to use with those synchros. The mainshaft end play was around 0.017" while it should be 0.002"-0.006". Fixed this with new bearings and shims and ended up with 0.003" play. The only gear that had evidence of any problems was the 5th gear countershaft gear. There was a small chip off one of the teeth. Other than that no noticeable problems. The engine had 250k on it before I bought it. The trans was never rebuild when the previous owner had it. He did tow a lot with it.
Looking to upgrade to a Fuller FSO 6406 or FSO 8406 6 speed down the road.
Found a B+W turnover ball gooseneck hitch in the wrecking yard out of a '01 Dodge 2500 and modified it to fit the frame of the '65. Worked out real well. It is bolted to the frame and is located about 12" in front of rear end.
Anyways, had a good towing trip this last weekend. Towed one of our modified pulling tractors to a truck/tractor pull in Hollister, Ca this last weekend. Gooseneck trailer and tractor weighed right at 12,000 lbs. Truck towed great. Got a little hot going up Cuesta grade but I still don't have a fan shroud on there yet. Other than that got about 10.5 mpg on a 340 mile round trip. Met two fellow Sweptliners up there. One had a '64 W100 short bed with a 408 stroker and another '68 W200 big block that was setup permanently for pulling.
Will get some pictures posted up when I get a chance.
Rob
Mountain Springs Power Wagon Service, Paso Robles, CA
1962 W100-340-LU2 winch
1964 W200-340-LU2 winch
1964 W300-318-LU2 winch
1965 W200 Crew Cab- Cummins Diesel
1965 W200 Cummins Project UPDATED 10/27/13
|
9733 |
PowerMan
|
01/16/2012 11:47PM |
Re: 1965 W200 Cummins Project
|
1970 |
Kaegi
|
01/17/2012 01:52AM |
Re: 1965 W200 Cummins Project
|
1770 |
PwrWgnDrvr
|
01/17/2012 09:02AM |
Re: 1965 W200 Cummins Project
|
1773 |
dougdodgeman
|
01/17/2012 09:16AM |
Re: 1965 W200 Cummins Project
|
1668 |
PwrWgnDrvr
|
01/17/2012 10:46AM |
Re: 1965 W200 Cummins Project
|
1652 |
Kaegi
|
01/17/2012 10:47AM |
Re: 1965 W200 Cummins Project
|
1610 |
PwrWgnDrvr
|
01/17/2012 11:56AM |
Re: 1965 W200 Cummins Project
|
1680 |
Kaegi
|
01/17/2012 12:38PM |
Re: 1965 W200 Cummins Project
|
1558 |
PwrWgnDrvr
|
01/17/2012 02:21PM |
Re: 1965 W200 Cummins Project
|
1571 |
Kaegi
|
01/17/2012 02:47PM |
Re: 1965 W200 Cummins Project
|
1685 |
PowerMan
|
01/17/2012 03:44PM |
Re: 1965 W200 Cummins Project
|
1657 |
Kaegi
|
01/17/2012 03:55PM |
Re: 1965 W200 Cummins Project
|
1657 |
PwrWgnDrvr
|
01/17/2012 04:24PM |
Re: 1965 W200 Cummins Project
|
1764 |
PowerMan
|
01/18/2012 01:01AM |
Re: 1965 W200 Cummins Project
|
1554 |
PwrWgnDrvr
|
01/18/2012 08:44AM |
Re: 1965 W200 Cummins Project
|
1491 |
Kaegi
|
01/17/2012 10:45AM |
Re: 1965 W200 Cummins Project
|
1799 |
JimmieD
|
01/17/2012 08:49PM |
Re: 1965 W200 Cummins Project
|
1540 |
JimmieD
|
01/17/2012 09:10PM |
Re: 1965 W200 Cummins Project
|
1450 |
PwrWgnDrvr
|
01/17/2012 09:59PM |
Re: 1965 W200 Cummins Project
|
1467 |
JimmieD
|
01/18/2012 11:54AM |
Re: 1965 W200 Cummins Project
|
1380 |
Kaegi
|
01/18/2012 07:30PM |
Re: 1965 W200 Cummins Project
|
1253 |
JimmieD
|
01/18/2012 11:38PM |
Re: 1965 W200 Cummins Project
|
1539 |
garyo
|
01/27/2012 01:28AM |
KDP fixed...
|
1645 |
PowerMan
|
01/27/2012 09:34AM |
Re: KDP fixed...
|
1390 |
Russ Roth
|
01/28/2012 12:35AM |
Re: KDP fixed...
|
1210 |
olypopper
|
10/16/2012 03:19PM |
Re: 1965 W200 Cummins Project
|
1223 |
JimmieD
|
01/29/2012 08:19AM |
Re: 1965 W200 Cummins Project
|
1355 |
War Wagon991
|
01/31/2012 07:19AM |
Re: 1965 W200 Cummins Project
|
1464 |
JimmieD
|
02/01/2012 07:20AM |
Re: 1965 W200 Cummins Project
|
1343 |
War Wagon991
|
02/14/2012 04:16PM |
Re: 1965 W200 Cummins Project
|
1387 |
Kaegi
|
02/06/2012 08:15PM |
Re: 1965 W200 Cummins Project
|
1243 |
JimmieD
|
02/15/2012 09:20AM |
Re: 1965 W200 Cummins Project
|
1284 |
PwrWgnDrvr
|
02/15/2012 12:14PM |
Re: 1965 W200 Cummins Project
|
1333 |
JimmieD
|
02/17/2012 08:50AM |
Re: 1965 W200 Cummins Project
|
1278 |
PwrWgnDrvr
|
02/17/2012 10:22AM |
Re: 1965 W200 Cummins Project
|
1321 |
Kaegi
|
02/17/2012 11:29AM |
Re: 1965 W200 Cummins Project
|
1384 |
JimmieD
|
02/17/2012 06:25PM |
Re: 1965 W200 Cummins Project
|
1286 |
Kaegi
|
02/17/2012 09:05PM |
Re: 1965 W200 Cummins Project
|
1429 |
Kaegi
|
02/19/2012 12:10PM |
Re: 1965 W200 Cummins Project
|
1463 |
JimmieD
|
02/18/2012 08:13AM |
Re: 1965 W200 Cummins Project
|
1452 |
MoparNorm
|
02/18/2012 11:29PM |
Update June 9, 2012
|
1619 |
PowerMan
|
06/10/2012 12:28AM |
Re: Update June 9, 2012
|
1258 |
PwrWgnDrvr
|
06/10/2012 08:46AM |
Re: 1965 W200 Cummins Project
|
1095 |
JimmieD
|
06/10/2012 08:50AM |
Update 2 June 10th
|
1494 |
PowerMan
|
06/10/2012 11:51PM |
Update 3 June 15
|
1663 |
PowerMan
|
06/16/2012 12:24AM |
Update September 9, 2012
|
1485 |
PowerMan
|
09/10/2012 12:04AM |
Re: Update September 9, 2012
|
1084 |
Phil
|
09/10/2012 04:00PM |
Re: Update September 9, 2012
|
1139 |
dougdodgeman
|
09/11/2012 07:56AM |
Re: Update September 9, 2012
|
1152 |
dougdodgeman
|
09/11/2012 08:28AM |
Re: Update September 9, 2012
|
1209 |
PowerMan
|
09/11/2012 02:38PM |
Re: 1965 W200 Cummins Project Updated September 9, 2012
|
1312 |
JimmieD
|
09/11/2012 07:42PM |
Sandblasted the Frame...Ready to Paint..
|
1478 |
PowerMan
|
09/11/2012 11:23PM |
Painted...
|
1375 |
PowerMan
|
09/12/2012 05:40PM |
Update Oct 7, 2012: Dana 80 installed..
|
1474 |
PowerMan
|
10/08/2012 12:25AM |
Re: 1965 W200 Cummins Project Updated October 28, 2012
|
1621 |
PowerMan
|
10/28/2012 10:27PM |
Re: 1965 W200 Cummins Project Updated October 28, 2012
|
1169 |
Kaegi
|
10/29/2012 08:41PM |
Re: 1965 W200 Cummins Project Updated October 28, 2012
|
1174 |
swptln
|
11/06/2012 10:44PM |
Re: 1965 W200 Cummins Project Updated October 28, 2012
|
1301 |
MoparNorm
|
11/08/2012 11:48AM |
December 9 2012 Update-- Dana 60
|
1456 |
PowerMan
|
12/09/2012 11:12AM |
December 12, 2012 Update
|
1379 |
PowerMan
|
12/12/2012 10:20PM |
Update December 30
|
1281 |
PowerMan
|
12/30/2012 11:18PM |
January 3, 2013 Update...
|
1055 |
PowerMan
|
01/03/2013 11:03PM |
January 4, 2013 Update: Started the Cummins...Video here...
|
1155 |
PowerMan
|
01/04/2013 09:34PM |
Re: January 4, 2013 Update: Started the Cummins...Video here...
|
1213 |
swptln
|
01/06/2013 08:32AM |
Re: 1965 W200 Cummins Project Updated January 4, 2013
|
1276 |
JimmieD
|
01/07/2013 09:48AM |
Feb 22, 2013 Update
|
1428 |
PowerMan
|
02/22/2013 11:48PM |
Feb 23, 2013 Update
|
1151 |
PowerMan
|
02/23/2013 11:16PM |
March 1, 2013 Update Driveline
|
1222 |
PowerMan
|
03/01/2013 11:11PM |
March 25, 2013 Update
|
1172 |
PowerMan
|
03/25/2013 10:53PM |
Re: March 25, 2013 Update
|
1092 |
exline
|
04/04/2013 10:20PM |
Re: March 25, 2013 Update
|
1002 |
wally426ci
|
04/11/2013 06:14AM |
Re: March 25, 2013 Update
|
1137 |
swptln
|
04/11/2013 07:17AM |
April 29, 2013 Update
|
1213 |
PowerMan
|
04/29/2013 10:04AM |
Re: April 29, 2013 Update
|
1112 |
olypopper
|
04/30/2013 02:25PM |
Re: April 29, 2013 Update
|
1253 |
Gordo
|
05/01/2013 01:02PM |
Re: April 29, 2013 Update
|
1219 |
PowerMan
|
05/02/2013 03:17PM |
Re: April 29, 2013 Update
|
1132 |
swptln
|
05/01/2013 08:33PM |
May 4, 2013 Update....
|
1365 |
PowerMan
|
05/04/2013 11:56PM |
Re: 1965 W200 Cummins Project Updated 5/4/13
|
1502 |
PowerMan
|
05/12/2013 08:21PM |
May 19, 2013 Update
|
1314 |
PowerMan
|
05/19/2013 11:03PM |
Re: May 19, 2013 Update
|
1198 |
swptln
|
05/21/2013 10:38AM |
6/9/2013 Update
|
1333 |
PowerMan
|
06/09/2013 10:02PM |
6/25/13 Update First Road Trip...Pictures
|
1463 |
PowerMan
|
06/26/2013 12:02AM |
Hollister Power Wagon Rally Pictures 2013
|
1751 |
PowerMan
|
06/26/2013 12:04AM |
Re: 6/25/13 Update First Road Trip...Pictures
|
1236 |
PwrWgnDrvr
|
06/27/2013 09:24AM |
Re: 6/25/13 Update First Road Trip...Pictures
|
1334 |
PowerMan
|
06/27/2013 07:03PM |
10/8/2013 Update
|
1243 |
PowerMan
|
10/08/2013 01:49PM |
Pictures....
|
1411 |
PowerMan
|
10/08/2013 01:50PM |
Re: 10/8/2013 Update
|
1020 |
BlownWagon
|
10/08/2013 08:03PM |
Re: 10/8/2013 Update
|
1175 |
PwrWgnDrvr
|
10/08/2013 10:57PM |
Re: 10/8/2013 Update
|
1109 |
swptln
|
10/09/2013 11:08AM |
10/27/2013 Update
|
1400 |
PowerMan
|
10/27/2013 10:37PM |
Re: 1965 W200 Cummins Project UPDATED 10/27/13
|
1232 |
PowerMan
|
11/22/2014 11:46PM |
Re: 1965 W200 Cummins Project UPDATED 10/27/13
|
1331 |
Cumminpwr11
|
12/20/2014 04:43AM |